2011 Volkswagen Jetta Recalls

Search Recalls
Volkswagen Jetta 2011

2011 VOLKSWAGEN JETTA

Report Date:
March 07, 2014
Campaign Number:
14E007000
Component:
ENGINE AND ENGINE COOLING:ENGINE

Summary:
The Gates Corporation (Gates) is recalling certain aftermarket Tru-Flow Water Pumps, part number TFW 41127, sold at certain NAPA Auto Parts and/or installed by automotive service technicians after November 1, 2013 (and manufactured August 2013 through October 2013) that have a black-colored pulley/sprocket or do not have 'US9377' stamped on the water pump housing. These service replacement parts were sold for use in model year 1999-2005 Audi A4, 2000-2006 Audi TT, 1998-2005 Volkswagen Beetle, 1999-2006 Golf, 1999-2008 and 2011-2013 Volkswagen Jetta, and 2000-2005 Volkswagen Passat. In the affected water pumps, the pulley or sprocket that turns the timing belt may develop microfractures causing the timing belt to fail.

Consequence Summary:
A failure of the timing belt may cause the engine to shut down, potentially increasing the risk of a vehicle crash.

Corrective Summary:
Gates will notify owners, and dealers will replace the water pump, free of charge. The recall began during May 2014. Owners may contact The Gates Corporation at 1-303-744-1911.

2011 VOLKSWAGEN JETTA

Report Date:
October 03, 2011
Campaign Number:
11V490000
Component:
FUEL SYSTEM, DIESEL

Summary:
VOLKSWAGEN IS RECALLING CERTAIN MODEL 2009-2012 JETTA AND JETTA SPORTWAGEN VEHICLES, MANUFACTURED FROM MAY 2008 THROUGH SEPTEMBER 2011, MODEL YEAR 2010-2012 VOLKSWAGEN GOLF VEHICLES, MANUFACTURED FROM MAY 2009 THROUGH SEPTEMBER 2011, AND MODEL YEAR 2010-2012 AUDI A3 VEHICLES, MANUFACTURED FROM SEPTEMBER 2009 THROUGH SEPTEMBER 2011, THAT ARE EQUIPPED WITH A 2.0L TDI COMMON RAIL DIESEL ENGINE/CLEAN DIESEL ENGINE. THE FUEL INJECTION PULSES COULD COINCIDE WITH THE NATURAL FREQUENCY OF THE INJECTOR LINE #2, IN SPECIFIC LOAD AND RPM CONDITIONS. THIS RESONANCE CREATES ADDITIONAL STRESS IN THE FUEL LINE.

Consequence Summary:
DUE TO THE RESONANCE CONDITION, INJECTOR LINE NUMBER 2 COULD DEVELOP SMALL CRACKS WHICH COULD LEAD TO FUEL LEAKAGE. LEAKING FUEL IN THE PRESENCE OF AN IGNITION SOURCE, MAY LEAD TO A FIRE.

Corrective Summary:
VOLKSWAGEN WILL INSTALL AN IMPROVED FUEL INJECTOR LINE FOR THE NUMBER 2 CYLINDER ON CERTAIN VEHICLES AND WILL INSTALL VIBRATION DAMPERS ON ALL OF THE INJECTOR LINES. VOLKSWAGEN AND AUDI WILL NOTIFY OWNERS TO HAVE THE VEHICLES REPAIRED FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

2011 VOLKSWAGEN JETTA

Report Date:
September 08, 2011
Campaign Number:
11E036000
Component:
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

Summary:
VOLKSWAGEN IS RECALLING CERTAIN STAINLESS STEEL EXHAUST TIPS, PART NUMBER 1K0 071 910 U, SOLD AS ACCESSORY EQUIPMENT FOR USE ON MODEL YEAR 2011-2012 JETTA SEDAN VEHICLES MANUFACTURED FROM MARCH 18, 2010, THROUGH AUGUST 22, 2011. THESE EXHAUST TIPS MAY EXTEND BEYOND THE ORIGINAL LENGTH OF THE FACTORY-INSTALLED EXHAUST PIPES. IT IS POSSIBLE FOR INADVERTENT CONTACT TO OCCUR WITH A PERSON'S LEG.

Consequence Summary:
IF THE TAILPIPE EXTENSION IS HOT DURING INADVERTENT CONTACT, A BURN COULD OCCUR.

Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE STAINLESS STEEL EXHAUST TIPS AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

2011 VOLKSWAGEN JETTA

Report Date:
September 07, 2011
Campaign Number:
11V466000
Component:
ENGINE AND ENGINE COOLING:EXHAUST SYSTEM

Summary:
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2011-2012 JETTA SEDAN VEHICLES MANUFACTURED FROM MARCH 18, 2010, THROUGH AUGUST 22, 2011. SOME VEHICLES HAD A STAINLESS STEEL EXHAUST TIP INSTALLED AT THE PORT DURING IMPORTATION. THESE EXHAUST TIPS MAY EXTEND BEYOND THE ORIGINAL LENGTH OF THE FACTORY-INSTALLED EXHAUST PIPES. IT IS POSSIBLE FOR INADVERTENT CONTACT TO OCCUR WITH A PERSON'S LEG.

Consequence Summary:
IF THE TAILPIPE EXTENSION IS HOT DURING INADVERTENT CONTACT, A BURN COULD OCCUR.

Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE STAINLESS STEEL EXHAUST TIPS AS NECESSARY FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING NOVEMBER 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.

2011 VOLKSWAGEN JETTA

Report Date:
March 29, 2011
Campaign Number:
11V196000
Component:
ELECTRICAL SYSTEM:FUSES AND CIRCUIT BREAKERS

Summary:
VOLKSWAGEN IS RECALLING CERTAIN MODEL YEAR 2011 JETTA VEHICLES, MANUFACTURED FROM MARCH 2010 THROUGH MARCH 2011. THESE VEHICLES MAY HAVE AN ELECTRICAL WIRING AND FUSE LAYOUT WHERE THE CONVERTER BOX IS PROTECTED BY THE SAME FUSE USED BY THE SIGNAL HORN AND THE ANTI-THEFT ALARM SYSTEM. SHOULD THAT FUSE BE BLOWN, THE CONVERTER BOX WILL BE DISCONNECTED FROM THE POWER SUPPLY WHICH, IN TURN, WILL SHUT OFF APPLICATIONS SUCH AS THE ENGINE MANAGEMENT SYSTEM, LIGHTING SYSTEM, AND WIPERS.

Consequence Summary:
SHOULD THIS HAPPEN WHILE THE VEHICLE IS BEING DRIVEN, THE ENGINE COULD STALL, OR THE HEADLIGHTS OR WIPERS COULD TURN OFF UNEXPECTEDLY, POTENTIALLY LEADING TO A CRASH WITHOUT WARNING.

Corrective Summary:
VOLKSWAGEN WILL NOTIFY OWNERS WHEN SUFFICIENT QUANTITIES OF REPAIRS KITS ARE AVAILABLE. DEALERS WILL SEPARATE THE WIRING FOR THE HORN AND THE THEFT PROTECTION HORN FROM THE POWER SUPPLY OF THE CONVERTER BOX AND ROUTE THE WIRES TO SEPARATE FUSES TO CORRECT THE CONDITION FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN DURING APRIL 2011. OWNERS MAY CONTACT VOLKSWAGEN AT 1-800-822-8987.