1999 OLDSMOBILE INTRIGUE

Report Date:
July 03, 2014
Campaign Number:
14V400000
Component:
ELECTRICAL SYSTEM:IGNITION

Summary:
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. General Motors LLC (GM) notified the agency on July 3, 2014, that they are recalling 5,877,718 model year 2000-2005 Chevrolet Impala and Monte Carlo, 1997-2005 Chevrolet Malibu, 1999-2004 Oldsmobile Alero, 1998-2002 Oldsmobile Intrigue, 1999-2005 Pontiac Grand Am and 2004-2008 Pontiac Grand Prix vehicles. In these models, the weight on the key ring and/or road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.

Consequence Summary:
If the key is not in the run position, the air bags may not deploy if the vehicle is involved in a crash, increasing the risk of injury.

Corrective Summary:
GM will notify owners, and dealers will install two key rings and an insert in the key slot or a cover over the key head on all ignition keys, free of charge. The recall began on September 9, 2014. GM's number for this recall is 14350.

1999 OLDSMOBILE INTRIGUE

Report Date:
April 08, 2009
Campaign Number:
09V116000
Component:
ENGINE AND ENGINE COOLING

Summary:
GENERAL MOTORS IS RECALLING 1,497,516 MY 1997-2003 BUICK REGAL, MY 1998-2003 CHEVROLET LUMINA, MONTE CARLO AND IMPALA, MY 1998-1999 OLDSMOBILE INTRIGUE, MY 1997-2003 PONTIAC GRAND PRIX VEHICLES EQUIPPED WITH A 3.8L V6 NATURALLY ASPIRATED ENGINE. SOME OF THESE VEHICLES HAVE A CONDITION IN WHICH DROPS OF ENGINE OIL MAY BE DEPOSITED ON THE EXHAUST MANIFOLD THROUGH HARD BRAKING.

Consequence Summary:
IF THE MANIFOLD IS HOT ENOUGH AND THE OIL RUNS BELOW THE HEAT SHIELD, IT MAY IGNITE INTO A SMALL FLAME AND MAY SPREAD TO THE PLASTIC SPARK PLUG WIRE CHANNEL AND BEYOND INCREASING THE RISK OF AN ENGINE COMPARTMENT FIRE.

Corrective Summary:
DEALERS WILL REMOVE THE SPARK PLUG WIRE RETENTION CHANNEL AT THE FRONT OF ENGINE AND INSTALL TWO NEW SPARK PLUG WIRE RETAINERS FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING MAY 2009. OWNERS MAY CONTACT CHEVROLET AT 1-800-630-2438, OLDSMOBILE AT 1-800-630-6537, AND PONTIAC AT 1-800-620-7668 OR HTTP://WWW.PONTIAC.COM OR HTTP:WWW.GMOWNERCENTER.COM.

1999 OLDSMOBILE INTRIGUE

Report Date:
February 17, 2009
Campaign Number:
09E005000
Component:
STEERING

Summary:
DORMAN IS RECALLING 979 STEERING KNUCKLES, DORMAN P/NOS. 697-902 AND 697-903, SOLD UNDER DORMAN'S "OE SOLUTIONSTM" BRAND NAME, AND NAPA P/NOS. 7-8502 AND 7-8503 WHICH WERE SOLD FOR REPLACEMENT USE ON THE VARIOUS VEHICLES LISTED ABOVE. A POTENTIAL MATERIAL OR DESIGN DEFECT COULD RESULT IN THE STEERING KNUCKLE BREAKING IN THE HUB AREA.

Consequence Summary:
A BROKEN STEERING KNUCKLE COULD RESULT IN LOSS OF STEERING CONTROL AND A POSSIBLE CRASH WITHOUT WARNING.

Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE DEFECTIVE STEERING KNUCKLES FREE OF CHARGE AND REIMBURSE THE REPAIR FACILITY OR OWNER FOR LABOR. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT DORMAN'S TOLL-FREE HOTLINE AT 1-800-523-2492 AND PRESS 5.

1999 OLDSMOBILE INTRIGUE

Report Date:
October 17, 2008
Campaign Number:
08E063000
Component:
STEERING

Summary:
DORMAN PRODUCTS IS RECALLING 3,900 INTERMEDIATE STEERING SHAFTS DORMAN PART NOS. 425-151, 425-152, AND 425-153, (SOLD UNDER DORMAN'S "OE SOLUTIONS" BRAND NAME), BALKAMP #'S 7-3057, 7-3058, 7-3059 (SOLD UNDER THE "NAPA" BRAND NAME), AND PLATINUM PARTS #'S 2425151, 2425152, AND 2425153 MANUFACTURED DURING THE MONTH OF SEPTEMBER 2007. THESE REPLACEMENT STEERING SHAFTS CAN BE USED ON THE VEHICLES LISTED ABOVE. THE WELD CONNECTING THE INNER TUBE TO THE OUTER TUBE MAY BE DEFECTIVE.

Consequence Summary:
IF THE WELD FAILS, LOSS OF STEERING COULD RESULT, POSSIBLY RESULTING IN A VEHICLE CRASH.

Corrective Summary:
DORMAN WILL NOTIFY OWNERS AND REPLACE THE STEERING SHAFTS FREE OF CHARGE. THE RECALL BEGAN ON OCTOBER 16, 2008. OWNERS MAY CONTACT DORMAN TOLL FREE AT 1-800-523-2492.

1999 OLDSMOBILE INTRIGUE

Report Date:
February 16, 2000
Campaign Number:
00V044000
Component:
SEAT BELTS

Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. SOME OF THESE VEHICLES WERE BUILT WITH REAR SEAT SHOULDER BELTS THAT COULD TWIST, ALLOWING THE WEBBING TO BE JAMMED IN THE RETRACTOR. WHEN THE SHOULDER BELT WEBBING BECOMES JAMMED IN THE RETRACTOR, THE SEAT BELT BECOMES UNUSABLE.

Consequence Summary:
THIS COULD PREVENT A PERSON FROM USING THE SEAT BELT SYSTEM, AND A RISK OF INJURY TO AN UNBELTED PERSON IN A CRASH WOULD BE INCREASED.

Corrective Summary:
DEALERS WILL REMOVE ANY TWISTS FROM THE REAR SHOULDER BELT(S) AND INSTALL CLIPS TO THE BELT WEB GUIDE TO PREVENT TWISTING.

1999 OLDSMOBILE INTRIGUE

Report Date:
October 05, 1998
Campaign Number:
98V241000
Component:
ENGINE AND ENGINE COOLING:COOLING SYSTEM:HOSE

Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH A 3.8L V6 ENGINE. SOME OF THESE VEHICLES WERE BUILT WITHOUT A HEATER HOSE CLIP WHICH COULD ALLOW THE HOSE TO SAG AND CONTACT THE OXYGEN SENSOR RESULTING IN A COOLANT LEAK.

Consequence Summary:
IF A COOLANT LEAK WERE TO OCCUR, AND LEAKING COOLANT CONTACTED THE HOT EXHAUST MANIFOLD, AN ENGINE COMPARTMENT FIRE COULD RESULT.

Corrective Summary:
DEALERS WILL INSTALL A HEATER HOSE CLIP.

1999 OLDSMOBILE INTRIGUE

Report Date:
May 15, 1998
Campaign Number:
98V102000
Component:
EXTERIOR LIGHTING:HEADLIGHTS

Summary:
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE OWNER MANUALS DO NOT CONTAIN THE REQUIREMENT INFORMATION PERTAINING TO THE VEHICLE HEADLAMP AIMING DEVICE. THIS DOES NOT COMPLY WITH REQUIREMENTS OF FMVSS NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT."

Consequence Summary:
IF THE HEADLAMP ASSEMBLIES ARE REPLACED, CUSTOMERS MAY NOT BE ABLE TO PROPERLY AIM THE HEADLIGHTS.

Corrective Summary:
OWNERS WILL BE MAILED AN OWNER MANUAL'S INSERT WHICH CONTAINS THE APPROPRIATE INFORMATION.