2005 CHRYSLER SEBRING

Report Date:
October 09, 2009
Campaign Number:
09E056000
Component:
SUSPENSION:FRONT:CONTROL ARM:LOWER BALL JOINT

Summary:
QUALIS AUTOMOTIVE IS RECALLING CERTAIN AFTERMARKET BALL JOINTS SOLD FOR USE ON CERTAIN PASSENGER VEHICLES. THE SOCKET MAY HAVE BEEN EXCESSIVELY HARDENED WHICH COULD CAUSE IT TO CRACK NEAR THE RETAINING RING GROOVE ALLOWING THE BALL STUD TO SEPARATE UNDER IMPACT LOAD. THE SUBJECT BALL JOINTS WERE SOLD AS FOUR PART NUMBERS, D10945, D10946, G10945, AND G10946. THE AFFECTED CONTROL ARMS, D10945 AND D10946, ARE STAMPED WITH THE FOLLOWING DATES ON THE BALL JOINTS: 134308, 135708, 100109, 102709, 104109, 105509, 107609, 108909, 110309, 113209, AND 116609. THE G10945 AND G10946 ARE THE SAME PART AS THE D10945 AND D10946 RESPECTIVELY. THEY ARE LABELED DIFFERENTLY DEPENDING ON THE AFTERMARKET CUSTOMER.

Consequence Summary:
SEPARATION OF THE BALL STUD FROM THE SOCKET OF THE BALL JOINT HOUSING WOULD ALLOW THE CONTROL ARM TO COLLAPSE AND THE WHEEL TO FOLD IN CAUSING LOSS OF STEERING CONTROL, POSSIBLY RESULTING IN A CRASH.

Corrective Summary:
QUALIS AUTOMOTIVE WILL REPLACE THE BALL JOINTS FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 9, 2009. OWNERS MAY CONTACT QUALIS AUTOMOTIVE AT 1-800-493-4128.

2005 CHRYSLER SEBRING

Report Date:
April 07, 2009
Campaign Number:
09E012000
Component:
EXTERIOR LIGHTING

Summary:
SABERSPORT IS RECALLING 16,270 COMBINATION CORNER AND BUMPER LAMP ASSEMBLIES OF VARIOUS PART NUMBERS SOLD FOR USE AS AFTERMARKET EQUIPMENT FOR VARIOUS PASSENGER VEHICLES. THESE HEADLAMPS FAIL TO CONFORM TO THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, "LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT." THESE LAMPS DO NOT CONTAIN THE REQUIRED AMBER SIDE REFLECTORS.

Consequence Summary:
DECREASED LIGHTING VISIBILITY MAY RESULT IN A VEHICLE CRASH.

Corrective Summary:
SABERSPORT WILL NOTIFY OWNERS AND OFFER A FULL REFUND FOR THE NONCOMPLIANT COMBINATION LAMPS. THE SAFETY RECALL BEGAN ON MAY 11, 2009. OWNERS MAY CONTACT SABERSPORT AT 1-909-598-7589.

2005 CHRYSLER SEBRING

Report Date:
March 29, 2007
Campaign Number:
07E023000
Component:
SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:MASTER CYLINDER

Summary:
CERTAIN CARDONE MASTER CYLINDERS WITH PART NUMBERS 10-2925, 10-2987, 10-2987MZA, 10-3083, 11-3015, 11-3042, 11-3044, 11-3045, 11-3047, 11-3064, AND 11-3156, AND WITH DATE CODES LOWER THAN DCA7078 SOLD AS REPLACEMENT EQUIPMENT FOR USE ON THE VEHICLES LISTED ABOVE. THE SEAL ON MASTER CYLINDER CAN FAIL AND LEAK BRAKE FLUID.

Consequence Summary:
LOSS OF BRAKE FLUID CAN RESULT IN POOR BRAKING PERFORMANCE, POSSIBLY RESULTING IN A VEHICLE CRASH.

Corrective Summary:
CARDONE WILL NOTIFY OWNERS AND OFFER TO REPURCHASE ANY DEFECTIVE MASTER CYLINDERS. THE RECALL BEGAN DURING APRIL 2007. OWNERS CAN CONTACT CARDONE AT 1-800-777-4780.

2005 CHRYSLER SEBRING

Report Date:
December 09, 2004
Campaign Number:
04V579000
Component:
STEERING:LINKAGES:KNUCKLE:SPINDLE:ARM

Summary:
ON CERTAIN SEDANS AND CONVERTIBLE MODEL VEHICLES, THE RIGHT STEERING KNUCKLE MAY HAVE BEEN DAMAGED DURING THE COMPONENT MANUFACTURING PROCESS.

Consequence Summary:
THIS COULD CAUSE THE STEERING KNUCKLE TO CRACK AND SEPARATE FROM THE UPPER CONTROL ARM, WHICH COULD RESULT IN A CRASH.

Corrective Summary:
DEALERS WILL INSPECT AND REPLACE THE RIGHT STEERING KNUCKLE. THE RECALL BEGAN ON DECEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.

2005 CHRYSLER SEBRING

Report Date:
November 02, 2004
Campaign Number:
04V532000
Component:
SEAT BELTS:REAR

Summary:
ON CERTAIN SEDANS, THE LEFT AND RIGHT REAR OUTBOARD RETRACTOR AND TURNING LOOP BOLTS ON THE SEAT BELTS MAY NOT HAVE BEEN PROPERLY TIGHTENED.

Consequence Summary:
IN THE EVENT OF A CRASH, THE SEAT OCCUPANT MAY NOT BE PROPERLY RESTRAINED, INCREASING THE RISK OF INJURY.

Corrective Summary:
DEALERS WILL INSPECT AND TIGHTEN THE AFFECTED FASTENERS. THE RECALL BEGAN ON NOVEMBER 15, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.